Sweep & inspection
Caps & crowns
Flue relining
Masonry repair
Gas fireplace serviceLevel 1 sweep and inspection to the NFPA 211 annual standard - flue, crown, cap, and flashing checked and photographed
Chimney sweep logs do not sweep chimneys. They loosen some creosote - which then falls where a brush and vacuum still have to collect it.
Chimney Company in Santa Ana, CA
Chimney repair in Santa Ana usually means working on a fireplace that hasn’t been touched in years. The city’s 1920s through 1950s bungalows and Spanish Revival cottages hold original masonry fireplaces with clay tile flues, and decades of Santa Ana winds plus occasional seismic settling have left cracked mortar joints and damaged crowns. We handle the full repair scope: liner installation, cap replacement, flashing work, and crown repair. When our sweep finds damage, we fix it without sending you to a second company. Call us at (877) 516-7159 for a free estimate.
Why Santa Ana Homes Are Different
Santa Ana’s warm, dry climate means most fireplaces sit idle for long stretches, then get pressed into service during a cold snap. That pattern creates a specific problem: creosote from occasional fires bakes onto flue walls and hardens into a glaze-like deposit that a standard brush won’t remove. Homes in Santa Ana, particularly the 1920s through 1950s bungalows that dominate neighborhoods like French Park and Wilshire Square, often have clay tile flues that were installed before modern liner standards existed. Those flues develop hairline cracks from decades of heating and cooling cycles, plus the ground settling common across Orange County. The frequent Santa Ana winds push dust and fine debris into chimneys at a rate you wouldn’t see in wetter climates. In the historic French Park and Wilshire Square neighborhoods specifically, the original 1920s tile roofs have clay chimney pots that are often cracked from years of wind exposure. Our technicians check those pots before sweeping so we don’t create a call-back situation or miss a repair that should have been flagged. When a homeowner in Santa Ana calls us after years of non-use, we walk in expecting hardened creosote and aging mortar joints, and we bring the equipment to handle both.
Styles & brands we work with
Our Main Santa Ana Services
Most Santa Ana homeowners call us about two things: a chimney that hasn’t been cleaned in years, and a dryer vent that’s quietly building up lint behind the wall. Both are fire risks, and both fall under the same specialized trade.
Chimney Sweep in Santa Ana
A proper chimney sweep in Santa Ana starts with an inspection of the flue and firebox, then moves to removing creosote, soot, and any debris the winds have pushed down the flue. Because many Santa Ana fireplaces sit unused for most of the year, we often find hardened, glaze-like creosote that requires rotary cleaning heads rather than a standard brush. The process also checks the clay tile flue for cracks that, left alone, become a repair job later. If you’re in a 1920s or 1930s bungalow and can’t remember the last time the flue was looked at, start with a sweep and let the inspection tell us what’s next. Chimney Sweep in Santa Ana covers the full process and what to expect.
Dryer Vent Cleaning in Santa Ana
Dryer vent cleaning is the service most Santa Ana homeowners don’t think about until the dryer starts taking two cycles to finish a load. Lint builds up inside the vent pipe behind the dryer, and in older Santa Ana homes those vent runs are often long, narrow, and rarely cleaned. That lint is combustible, and it’s one of the leading causes of residential fires in the US. We clean the full vent run from the dryer connection to the exterior termination, then verify airflow with a meter so you know the line is actually clear. In bungalows where the dryer sits in a converted back porch or garage, the vent run can be unusually long, which makes the cleaning more involved. Dryer Vent Cleaning in Santa Ana explains the process and the signs that your vent needs attention.
What happens when you call
- 1
A real person answersNo phone trees — you reach a local pro.
- 2
You get an upfront price rangeHonest numbers before anyone is dispatched.
- 3
A background-checked tech heads outLicensed & insured, dispatched right away.
- 4
You approve before work beginsNothing starts until you say go.
Chimney Repair in Santa Ana
Chimney repair in Santa Ana typically means addressing what the sweep uncovered: cracked clay tiles, a rusted cap, a leaking flashing, or a crumbling crown. Homes here were built before modern stainless steel liners became standard, so the original clay flue is often the weak point. After decades of Santa Ana winds, occasional cold-snap fires, and Orange County seismic settling, those flues crack and spall. That matters because a cracked flue lets heat and gases reach the surrounding masonry and framing. Our team handles Chimney Repair for the full scope: liner installation, cap replacement, flashing repair, and crown repair. We use DuraFlex flexible liner systems for relining work and HeatShield for resurfacing when a full liner replacement isn’t necessary.
Chimney Cap Replacement
Signs you need it
Your existing cap is rusted through, missing, or has gaps that let rain, birds, and Santa Ana wind-blown debris into the flue.
What it costs in Santa Ana
Chimney cap replacement in Santa Ana typically runs $250 to $600 depending on the flue size and whether a custom cap is needed for an older clay tile flue.
How we do it
We measure the flue opening, remove the old cap, and install a properly sized replacement, usually a Famco or Copperfield unit, secured to the crown with the right fasteners for the flue type.
Chimney Liner Installation
Signs you need it
Your clay tile flue shows cracked or spalled sections during a camera inspection, or the smoke chamber is no longer safely containing combustion gases.
What it costs in Santa Ana
Chimney liner installation in Santa Ana ranges from $2,200 to $5,000 for a full DuraFlex flexible liner system, depending on the flue height and access difficulty on older bungalow roofs.
How we do it
We size the liner to the flue dimensions, lower it from the roof, insulate where the clearances require it, and connect it at the appliance and the top plate with a new cap.
Chimney Flashing Repair
Signs you need it
You see water staining on the ceiling or walls near the chimney, or the flashing visible at the roofline has gaps, lifted edges, or cracked sealant.
What it costs in Santa Ana
Chimney flashing repair in Santa Ana typically costs $400 to $1,200, with the higher end covering replacement of rusted flashing sections where the chimney meets a tile roof.
How we do it
We remove the old flashing, inspect the underlying mortar and roofing for damage, install new stepped flashing that interleaves with the roof material, and seal all seams with a polyurethane sealant.
Chimney Crown Repair
Signs you need it
The concrete crown at the top of your chimney has visible cracks, spalling, or has separated from the flue tile, allowing water to soak into the chimney structure.
What it costs in Santa Ana
Chimney crown repair in Santa Ana runs $350 to $900 for a standard resurfacing, with full crown rebuilding priced by size when the existing concrete has failed beyond patching.
How we do it
We clean the existing crown, cut out loose concrete, apply a proper crown coat with a slight slope away from the flue, and tool a drip edge so water drains off instead of soaking into the masonry.
What Chimney Repair Costs in Santa Ana
| Item | Typical range in Santa Ana |
|---|---|
| Chimney cap replacement | $250 – $600 |
| Chimney flashing repair | $400 – $1,200 |
| Chimney crown repair | $350 – $900 |
Liner work goes higher because the material and access both cost more on Santa Ana’s older roofs. Every repair quote is fixed before we start, and we show you the camera footage so you see exactly what we’re proposing to fix.
How long does chimney repair take in Santa Ana?
Most cap replacements and crown repairs are done in a single visit. A full liner installation typically takes one day, though access issues on steep Spanish Revival roofs can add time.
My chimney only smokes a little. Can I wait on repairs?
A cracked flue doesn’t improve with time. The smoke you see is a sign that combustion gases aren’t exiting cleanly, and the longer the flue stays damaged, the more heat reaches the surrounding masonry. Call (877) 516-7159 and we’ll camera-inspect it before recommending anything.
Brands We Service in Santa Ana
We work with contractor-grade chimney brands including DuraFlex, Famco, and Copperfield. These are the same supplier lines used by professional chimney companies, not hardware-store substitutes, and that means the parts we install on Santa Ana homes are built for the specific conditions of an older masonry flue. Our brands page details the full lineup and why the material matters when something sits on top of your chimney for a decade.
See the difference
Before
After
Before
After
Before
AfterPricing for Chimney Company in Santa Ana, CA
| Service | Typical range in Santa Ana |
|---|---|
| Chimney sweep | $180 – $320 |
| Chimney cap installation | $250 – $600 |
| Chimney cap replacement | $250 – $600 |
| Chimney liner installation | $2,200 – $5,000 |
| Chimney flashing repair | $400 – $1,200 |
| Chimney crown repair | $350 – $900 |
| Dryer vent cleaning | $125 – $275 |
What pushes a price toward the top of the range in Santa Ana is access: older bungalow roofs with steep pitches, clay chimney pots that need careful handling, and flue heights that require more liner material. Every job is quoted as a flat price before we start, so you know the number before any tool comes off the truck.
Neighborhoods We Serve in Santa Ana
We work throughout Santa Ana, including the older housing stock where chimney conditions are often the most neglected. Our service area covers ZIP codes 92701, 92702, 92703, and 92799, and we schedule by area so a call in the morning gets you a visit without driving all over Orange County.
- French Park
- Wilshire Square
- Floral Park
- Washington Square
- Morrison Park
Service Area – Cities Near Santa Ana
San Bernardino Chimney Sweep also serves the surrounding Orange County communities where the housing stock is similarly aged and the chimney conditions run the same patterns we see in Santa Ana. If you’re in Tustin, CA, North Tustin, CA, Fountain Valley, CA, or Orange, CA, call us at (877) 516-7159 and we’ll route the visit from our Santa Ana scheduling area.
Serving Santa Ana, CA — Our Local Coverage Area
We’re based in the Santa Ana area and know this community well. Use the map below to see our service coverage — if you’re nearby, we can almost certainly help.
FAQs About Chimney Company in Santa Ana
We schedule chimney and dryer vent work in Santa Ana on a set route, so most visits can be booked within a few days. If you call early in the week, we can usually get to you before the weekend. Call (877) 516-7159 for the next available slot.
Most standard chimney repairs and routine sweeping do not require a city permit in Santa Ana. A full liner installation that changes the flue configuration may require a permit depending on the scope. We handle the determination for every job so you don’t have to guess.
Yes. We work on single-family homes, duplexes, and larger rental properties throughout Santa Ana, including homes in the 92701 and 92703 ZIP codes. Property managers should call (877) 516-7159 to schedule multi-unit visits on a single route stop.
What happens when you call
- 1A real person answersNo phone trees — talk to a local chimney cleaning pro.
- 2You get an upfront price rangeHonest numbers before anyone is dispatched. No surprises.
- 3We come out and measureLicensed & insured, at a time that suits you — the visit and the quote are both free.
- 4You get the price in writingLine-itemed, yours to keep, and nothing starts until you say go.
What Santa Ana Customers Say
"Crown was cracked and taking water. Repaired it rather than quoting a rebuild, which the previous company had pushed hard for."
— Jason Brooks"Cap keeps the birds out now, which after two springs of scratching noises is worth every penny."
— Rafael Torres"Liner was cracked in two places. He walked me through the repair options honestly, including the one that was cheaper for him and better for me."
— Priya Rao